Pruning is one of the most critical viticultural practices to influence vine balance, canopy structure, yield and grape composition. Traditionally, pruning is performed by hand, representing a significant labour cost in vineyard management. Even with the introduction of pre-pruning and the use of assisted pruning shears, pruning represents about 30 % to 36 % of the hand labour required in a vineyard (Martinez-de-Toda & Sancha, 1999). The implementation of mechanised pruning systems has been shown to significantly increase grapevine yield (Lopes et al. 2000; Keller & Mills, 2007). Typically, this increase in production is not associated with a decline in grape quality (Gatti et al., 2011), except when yield exceeds the vine’s productive capacity (Bovio & Lisa, 1996). In many cases, mechanised pruning may even contribute to improved grape quality (Clingeleffer, 2009).

Adaptation to mechanical pruning occurs when the yield increase resulting from a higher bud load is balanced by greater canopy efficiency (Poni et al., 2004). This balance can be achieved through the use of free growing canopies, which have higher overall photosynthetic rates compared with positioned canopies (Poni & Intrieri, 2001), if interrow width is maintained.

The application of municipal solid waste compost (MSWC) is a sustainable soil management strategy that enhances soil fertility, increases soil organic matter content and reduces the use of synthetic fertilisers (Diacono & Montemurro, 2010). Although MSWC has shown positive effects on vine performance (Messiga et al., 2015; Botelho et al., 2020a), the influence of different application rates on vegetative and reproductive growth, and grape and wine quality is not yet fully understood.

The application of organic amendments affects the chemical properties of soils, thus increasing the availability of nutrients (Illera-Vives et al., 2015; Botelho et al., 2021a), changing the nutrient status of the vine and affecting wine composition (Morlat & Symoneaux, 2008). In other studies, MSWC increased yield with no significant effects on wine colour and total phenols and only with slight differences in sensory analysis (Botelho et al., 2022).

Grapevines self-regulate the balance between the growth of roots, shoots and fruit (Keller, 2015). Mechanical pruning significantly increases bud load and as a consequence triggers self-regulation mechanisms that affect yield, namely a reduction in budburst (Botelho et al., 2020a), bud fertility (Byrne & Howell, 1978) and cluster weight (Christensen et al., 1994).

The objective of this study was to determine whether increasing soil fertility through progressive doses of MSWC can mitigate the impact of self-regulation mechanisms in mechanically pruned vines, thereby maintaining or enhancing vegetative and reproductive growth. Because yield and, in particular, leaf-to-fruit ratio influence grape and wine composition, this study also aims to assess the interactive effects of these two practices on grape and wine quality.

In Table 2, the productivity parameters results are presented. Mechanical pruning significantly increased the cluster number per vine over the four years of the trial. Although no differences in cluster weight between pruning systems were recorded, a slight tendency was observed in 2018 and 2020. In a global analysis, when compared to hand pruning, mechanical pruning significantly increased yield over the four years of the trial (28 %).

The application of MSWC to the vineyard had no effect on productivity parameters, even after a few years of application.

The effects of mechanical pruning and the soil organic amendment in terms of vigour and vegetative expression are presented in Table 3.

Regarding mechanical pruning, there was a tendency for higher shoot number per vine, which was significantly different in 2018 and 2020. By contrast, shoot weight was significantly lower for mechanical pruning. Finally, the pruning weight per vine was significantly lower for mechanical pruning in 2019 and 2021.

The application of MSWC had no significant effects on shoot number per vine or pruning weight per vine. Even in terms of shoot weight, the differences between organic amending treatments were significant in 2020 only, when M3 had significantly heavier shoots, compared to M0.

Table 4 presents the effects of the pruning system and the organic amendment on the balance between vegetative and reproductive growth (Ravaz Index), and on total dry matter production.

It is worth noting that the Ravaz Index is significantly lower in hand pruning than in mechanical pruning. Conversely, although dry matter production was not significantly affected by the pruning system, except in 2020, the results show a tendency for slightly higher values in mechanical pruning.

The soil organic amendment had no significant effects on the Ravaz Index or the total dry matter production. Moreover, when the results of each treatment over the years was compared, no consistent trend was observed.

The effects of the pruning system and MSWC doses on the physicochemical characteristics of the wine are presented in Table 5. Alcoholic strength was significantly higher in MEC in 2018 and 2020, pH was not affected by the pruning system, total acidity was slightly lower in MEC in 2020 and volatile acidity was somewhat higher in MEC in 2018 and 2020.

Wine classical parameters were not significantly affected by MSWC application in any of the studied years.

The pruning system had no significant effects on the phenolic composition of the wines (Table 6). However, chromatic characteristics were somewhat affected by the pruning system. In 2019 and 2020, wine clarity was significantly different between pruning systems, though the differences were small and inconsistent. On the other hand, “a” and “b” tended to be higher in MAN, although the differences were significant only in one year (2018 for “a” and 2020 for “b”). The chroma values were tendentially higher in MAN, while hue was significantly higher in MEC in 2018.

Wines phenolic compositions and chromatic characteristics were not significantly affected by MSWC application to soil, except for hue in 2020 which was significantly higher in M0 than in M1.

Table 7 presents the results of the variation in colour (ΔE) and hue (∆H) between the different treatments. The differences in colour were highest in 2020. No significant differences were observed between the MSWC treatments and, as in pruning system, ΔE was higher in 2020. When comparing the three years, ∆H was also highest in 2020, the values were tendentially higher between MSWC treatments than between pruning systems.

The results of the sensorial analysis, namely those related to visual and olfactory characterisation, are presented in Table 8.

In terms of visual attributes, the wines of 2018 and 2019 were greener, showing a more youthful colour than those from 2020, whose colour was characterised by the tasters as tending towards yellow rather than green. The studied treatments had no significant effects on the visual aspects of the wines in any year of the trial.

In terms of olfactory aspects, mechanical pruning resulted in some significant differences in 2018 and 2019, but not in 2020: the 2018 wines from MEC had less intense cat pee and vegetal aromas, while the 2019 wines had lower aroma intensity and balance. However, from a practical point of view, the observed differences were negligible (equal to or less than 4.9 %), despite being statistically significant.

In terms of the effects of soil organic amendment on wine aroma, significant differences between treatments were observed only in 2019. Wines from M3 showed more intense aromas than those from M0 and M1, and fruitier aromas than M0.

Data regarding the wine gustatory attributes and overall appreciation are presented in Table 9. Mechanical pruning had a few but mostly negligible effects on wine in the mouth sensorial analysis. Only in 2019 was the acidity somewhat lower in MEC (1.8 %) and in 2020 the taste intensity was also slightly lower in MEC (2.7 %).

Except for wine body, soil organic amendment had no effects on taster palate perception in 2019. Wines from M3 and M1 had significantly more body than M0 in 2019, but the difference was not substantial (6.3 % and 6.6 % respectively).

The effects of mechanical pruning on cluster number per vine (Table 2) are positive, with a significant increase in this variable every year of the trial. These results are consistent with the literature (Barcia et al., 2023; Allegro et al., 2022; Botelho et al., 2020a) and are due to the higher bud number per plant which, in spite of the lower budburst percentage, leads to a higher shoot number and, thus, higher cluster number per plant (Martinez-de-Toda & Sancha, 1999; Geller & Kurtural, 2013). Additionally, in MAN there is usually a higher proportion of water shoots than in MEC (Botelho et al., 2020a), which are less fruitful shoots (Champagnol, 1984) that produce smaller clusters (Wolpert et al., 1983).

The pruning system had no significant effect on cluster weight in any of the assessed years, although a tendency for lighter clusters in MEC was observed in 2018 and 2020. While most studies have found mechanical pruning to result in significantly lighter clusters (Martinez-de-Toda & Sancha, 1999; Poni et al., 2004; Geller & Kurtural, 2013), some have not found any differences in cluster weight (Barcia et al., 2023). Regarding canopy architecture, MEC is an unfolded canopy (Carbonneau & Cargnello, 2003), while MAN is vertical shoot position trained and free canopies are known to have higher light interception within the canopy (Botelho et al., 2020a) and, consequently, a higher overall net photosynthesis than vertical shoot positioned canopies (Intrieri et al., 1997). Moreover, the present trial was carried out on flat terrain in a valley, and with minimal water restriction. Thus, despite the higher cluster number per vine, MEC vines compensated for the cluster weight and no differences were recorded, probably due to canopy architecture and sufficient water supply.

Although no significant differences were recorded in 2018, overall yield was significantly higher in MEC. This has been observed by several other authors (Lopes et al., 2000; Keller & Mills, 2007; Allegro et al., 2022) and is the result of the higher cluster number per vine, which was not compensated for a significant decrease in cluster weight.

The soil organic amendment had no significant effect on yield components, which is consistent with the results reported by Pinamonti (1998) but contrasts with the findings of Messiga et al. (2015) and Botelho et al. (2020a). In particular Botelho et al. (2020a) observed an increase in yield with the application of 16,100 kg/ha/year, which is due to the higher number of clusters per vine. However, in the present study, all treatments underwent fertilisation (40 kg N ha^–1), which may have overshadowed the effect of the MSWC. According to the literature, because MSWC is composted, N mineralisation rate is less than 15 % (ranging from 5 % to 15 %) of the total N supplied by the compost, followed by an annual release of 2 % to 8 % of the remaining compost-N in subsequent years (Amlinger et al., 2003). Therefore, the primary N source during the trial was the inorganic fertiliser, which was applied uniformly across all treatments. The nitrogen rate application that maximises yield is between 30 and 40 kg N ha^–1 (Visconti et al., 2023) which is the nitrogen application rate provided by the applied fertiliser. Since nitrogen is a key nutrient for both the vegetative and reproductive growth of vines, and is the limiting nutrient in this case, as phosphorus and potassium levels in the soil were adequate (Soveral-Dias et al., 1980), no differences were observed between the various MSWC doses.

The shoot number per vine was tendentially higher in MEC, as observed by other authors (Clingeleffer & Krake, 1992; Bovio & Lisa, 1996). This increase in shoot number per vine is due to the increase in bud load (Clingeleffer & Krake, 1992) which, despite a lower budburst percentage (Botelho et al., 2020a), still gives rise to a higher shoot number.

Shoot weight and pruning weight per vine were significantly lower in MEC, as reported by other authors (Martinez-de-Toda & Sancha, 1999; Botelho et al., 2020a). The decrease in these variables is related to the increase in shoot number that reduces the individual growth of each shoot (Botelho et al., 2012) and to the increase in reproductive growth that competes for assimilates with vegetative growth and, consequently, reduces total pruning weight per vine (Edson et al., 1993).

Regarding the effect of MSWC on vegetative growth parameters, no significant differences were observed, except for shoot weight in 2020, when M3 shoots were significantly heavier than M0. In contrast to the results of Botelho et al. (2020a), who reported an increase in shoot number, shoot weight and total pruning weight after three years of MSWC application, the present study showed minimal significant effects. However, in the aforementioned study, none of the treatments were supplemented with inorganic fertilisers to provide nitrogen. As a result, the only nutrient source was the organic amendment, leading to significant differences between the control and amended treatments. In contrast, in the present study, all treatments underwent an annual nitrogen fertilisation of 40 kg/ha. Given the low mineralisation rate of MSWC, the nitrogen supply across treatments remained similar, which likely explains the absence of significant differences in vegetative growth parameters.

Mechanical pruning significantly increased the Ravaz Index throughout the trial. Similar results have been reported by other authors (Botelho et al., 2020a), who attributed this increase to a higher yield and a reduction in pruning weight. However, the observed values remain below the optimal range of 6 to 10, as proposed by Smart et al. (1990), indicating low yields and excessive shoot vigour. Nevertheless, the higher Ravaz Index values in MEC treatments are closer to the ideal range compared to MAN, suggesting a better balance between vegetative and reproductive growth.

Although the differences were significant in 2020 only, the effect of mechanical pruning on total dry matter production was tendentially positive. This result is in accordance with other authors (Martinez-de-Toda & Sancha, 1999; Botelho et al., 2020b) and is probably the consequence of the different canopy architecture between pruning systems. In fact, free canopies have a better light microclimate in the canopy (Botelho et al., 2020a). As a consequence, free canopies achieve higher global net photosynthesis and higher assimilate production than vertical shoot positioned canopies (Intrieri et al., 1997).

Soil organic amendment had no significant effect on either the Ravaz Index or total dry matter production. The absence of differences in the Ravaz Index, previously reported by other authors (Botelho et al., 2020a), is likely due to the lack of variation in yield or pruning weight across MSWC doses. The lack of differences in dry matter production is probably related to the similar nitrogen supply between treatments, as dry matter production in non-restrictive light conditions is positively correlated with nitrogen supply (Keller & Koblet, 1995).

The analysis of alcoholic strength revealed a significantly higher value in MEC, which contradicts the findings of Holt et al. (2008) and Botelho et al. (2021b). These authors reported lower sugar accumulation in mechanically pruned systems, leading to wines with lower alcoholic strength. They attributed this reduction in sugar content to delayed maturation, which is associated with increased production due to the higher bud load.

MEC had tendentially higher values of ELA (Table S1) in three out of four years, revealing a higher photosynthetic potential. Moreover, the carbon balance, calculated according to Carbonneau (2026), indicates a tendency towards a higher carbon availability for grapes in MEC (Carbonneau & Torregrosa, 2020). In fact, the higher ELA, which is associated with lower vigour in the mechanically pruned treatment, results in a higher carbon balance and in turn to grapes with higher sugar content (Carbonneau & Torregrosa, 2020).

Moreover, although ELA did not significantly differ between pruning systems, the canopy architecture in MEC led to a less dense canopy, with higher light interception inside the canopy (Table S1). Since the increase in PAR inside the canopy was within the range where the increase in photosynthetic rate was higher (Rogiers & Clarke, 2013), it can be concluded that a higher proportion of leaves was photosynthesising at high rates in MEC at any given time, and the overall canopy photosynthetic rate in MEC was higher than in MAN, as reported by Intrieri et al. (1997).

In fact, Intrieri et al. (1997) reported a 26 % increase in overall plant photosynthesis in free-growing canopies compared to positioned ones, as a greater proportion of leaves are exposed to sunlight at any given time. Moreover, in free-growing canopies, leaves alternate rapidly between light and shade, leading to higher photosynthetic efficiency (Poni & Intrieri, 2001). This increase in overall plant photosynthesis likely compensated for the higher yield, as total leaf area per plant typically remains similar between hand and mechanical pruning (Botelho et al., 2020a).

Although free canopies have a higher plant overall photosynthetic rate, they require a higher interrow width than VSP, allowing the use of machinery in the vineyard. Since VSP can work with lower interrow widths, the system may compensate for the lower canopy efficiency by narrowing interrow. However, in the present case, the interrow width was the same in both pruning systems, thus the MEC system had a higher photosynthetic rate per hectare, leading to higher overall sugar production and, consequently, to wines with higher alcoholic strength.

The application of MSWC did not affect wine alcoholic strength, as already reported by previous studies (Mugnai et al., 2012; Botelho et al., 2022), and is probably related to the lack of differences in yield between treatments.

Wine pH was not significantly affected by any of the factors studied. This is consistent with previous findings, where no significant differences in pH were reported in response to mechanical pruning (Keller & Mills, 2007; Allegro et al., 2022). Although pH differences are often associated with delayed ripening (Conde et al., 2007) (a common outcome of mechanical pruning (Botelho et al., 2021b; Botelho et al., 2022)), such a delay was not observed in the present study.

Total acidity was tendentially lower in MEC, although the differences were not important from a technical point of view. Several other authors have found no differences in total acidity with mechanical pruning (Holt et al., 2008; Kurtural et al., 2019), despite an occasional tendency for a delay in ripening that leads to higher acidities (Clingeleffer & Krake, 1992). Concerning MSWC effects on total acidity, no differences were found between the different doses, as observed in other studies (Mugnai et al., 2012; Botelho et al., 2020c; Botelho et al., 2021b; Cataldo et al., 2022).

The impact of MEC on wine alcoholic strength (slight increase) and total acidity (slight decrease) are not in line with new market trends, which favour wines with less alcohol. However, in the present study the harvest of all treatments was performed on the same day; therefore, if the harvest of MEC had been performed earlier, the wines may have had lower alcoholic strength and higher acidity. An earlier harvest is of particular interest in the Lisbon wine region to potentially prevent Botrytis cinerea infections, since late September rain is common. Concerning the incidence of fungal diseases in vineyard, although MEC increases shoot density (Table 3), the different canopy architecture leads to a lower leaf area density and, consequently, to a higher sunlight penetration within the canopy (Table S1); this lower canopy density reduces fungal disease infections, such as powdery mildew (Austin et al., 2011). Moreover, the higher number of clusters in MEC lead to less compact clusters, that are less prone to Botrytis cinerea infections (Schäfer et al., 2021).

From a social point of view, mechanical pruning helps to solve the lack of specialised hand-labour for pruning, which is an emerging problem that concerns most winegrowers.

Total phenols, as well as flavonoids and non-flavonoids, were not significantly affected by either pruning or MSWC. The lack of influence of mechanical pruning on phenolic composition is consistent with the results obtained by other authors (Pérez-Bermúdez et al., 2015; Botelho et al., 2022). No MSWC effects on phenolic composition were observed, as has been reported in the literature (Cataldo et al., 2022). Some studies have reported a decrease in total phenols with a significant yield increase only due to MSWC application to the soil (Botelho et al., 2022). However, in the present work, no increases in yield were recorded and, thus, no decrease in total phenols was expected.

The wine colour, evaluated using CIELab parameters, showed high levels of clarity; despite being significantly different between pruning treatments, the differences were so small that they are probably not of technological importance. The a* values are significantly different between pruning treatments in 2018 only, showing that MEC wines are less green than MAN ones (Cosme et al., 2008). However, the obtained values a relatively low compared to the values reported by other published work (Cosme et al., 2008; Antoce et al., 2016; Silva et al., 2024), indicating that these wines do not have an intense green colour. The b* values of MEC are significantly lower in 2020, indicating less yellow wines (Cosme et al., 2008). The recorded values are similar to those obtained for Muscat Ottonel (Antoce et al., 2016), but lower than those obtained for Arinto and Muscat d’Alexandrie (Silva et al., 2024). Although some significant differences were recorded, the tasters were not able to detect them in the sensory analysis (Table 5).

The wine chroma was relatively low compared to the results of other studies (Cosme et al., 2008), which is typical of wines with low colour intensity. The hue results show that all the wines are close to 90, indicating wines with a predominantly yellow colour (Pissarra et al., 2005) and thus corroborating the a* and b* parameter results. MSWC had no significant effects on the CIELab parameters, except for hue in 2020, when M1 was significantly lower than M0; however, the difference is so small (less than 2 %) that it is not of technical interest.

An analysis of the colour differences between treatments revealed ΔE values which indicate differences in colour in 2018 and 2019 that cannot be distinguished by tasters (Spagna et al., 1996), even the experienced ones (Mokrzycki & Tatol, 2011). However, in 2020, the ΔE values showed differences in colour between pruning systems and MSWC treatments (values between 1 and 2) that can be detected only by experienced tasters (Mokrzycki & Tatol, 2011), despite no differences being detected in the sensory analysis (Table 8).

The sensory analysis revealed small differences across treatments, namely in the cat pee and vegetal aromas in 2018, which were more intense in hand pruning. These aromas are important in Sauvignon wines, as they are preferred by a high proportion of consumers (King et al., 2011). The cat pee aroma is associated with volatile thiols, which, rather than being affected by grape exposure (Martin et al., 2016), seem to be related to vine nitrogen status (Helwi et al., 2016). According to Botelho et al. (2021a), MEC tendentially reduces vine nitrogen status due to growth-induced dilution; therefore, it can be hypothesised that the cat pee aroma was less evident due to the nitrogen reduction in MEC. However, vegetal aromas are related to methoxypyrazine (King et al., 2011). The concentration of this flavour is significantly reduced by grape exposure to sunlight (Martin et al., 2016). In 2019, wines from MAN had slightly higher aroma intensity and balance. Botelho et al. (2022), working with Syrah, also found slight, but significant, decreases in aroma balance with mechanical pruning. However, despite some differences between pruning systems in terms of olfactory attributes, the tasters did not differentiate the wines in either of the treatments, as highlighted by the general appreciation results. Tasters also found some slight differences in acidity in 2019, with MAN wines being perceived as more acid than MEC; however, the difference is very small (0.06 points) and is not corroborated by laboratorial analysis (Table 4).

MSWC application also led to slight differences in wine aroma, namely in 2019 with the higher MSWC doses leading to fruitier and more balanced wines. Furthermore, in 2019, the application of MSWC led to more bodied wines with higher overall appreciation. These results contrast with those obtained by Botelho et al. (2022), who found no significant differences in fruity aroma, a tendency for less balanced aromas, less body and lower overall appreciation. However, in the referred work, the MSWC treatments produced significantly higher yields, which probably affected the results.

The effect of the interaction between mechanical pruning and soil amendment with MSWC on vine performance and wine quality was studied over 4 years. The results show a significant increase in yield with mechanical pruning, as well as an increase in sugar content, thus indicating higher canopy efficiency. The results of the overall analysis showed that the pruning system did not affect wine characteristics or quality (classical parameters, colour, phenolic compounds and sensory profile), indicating that this is a viable option for pruning Sauvignon in this terroir, which reduces costs and increases vineyard profitability.

The application of MSWC to the soil did not affect yield or its parameters. In the present study the soil amendment with MSWC was accompanied by an application of nitrogen, that may have overshadowed the effect of the MSWC. Although a primary analysis indicates that the application of MSWC to soil may not be a profitable practice, other side effects may be considered to justify it; i.e., the potential increase in soil water-holding capacity resulting from the rise in soil organic matter content (Table S2), which in non-irrigated vineyards may be crucial in the increasingly frequent dry years.

Thus, mechanical pruning is a powerful tool for the sustainable intensification of the vineyard, increasing yield and profitability and having almost no impact on the environment. Despite MSWC not contributing to vineyard profitability in the present study, in certain conditions it may be possible to use it as a tool for increasing vineyard resilience.

The research work was funded by PDR2020 (Measure 1.0.1/2016, partnership nº 82, initiative 164 – IntenSusVITI) and by FCT – Fundação para a Ciência e Tecnologia, I.P. through project reference UID/04129/2025 (LEAF Research Centre). E Borges da Silva was funded by CEF (UIDB/00239, CHANGE Associated Laboratory (LA/P/0121/2020 - https://doi.org/10.54499/LA/P/0121/2020) and TERRA Associated Laboratory (LA/P/0092/2020 - https://doi.org/10.54499/LA/P/0092/2020).